由于镜场辐射投射到吸热器受热面上同一目标点（即单点聚焦），造成塔式太阳能腔式吸热器受热面热负荷呈现时间和空间分布的不均匀现象，导致系统工质流量分配特性恶化。搭建用于模拟蒸发受热面水动力特性的试验装置，利用低电压大电流变压器加热，得到各管流量分配及壁温分布规律。从试验角度弥补了腔式吸热器受热面的水动力特性研究的空白，有利于实现腔式吸热器向大容量、高效率、规模化方向发展。
On account of one-target focus type of the heliostats in the tower solar power technology, the heat flux in the cavity receiver is non-uniform in time and space, which may lead to the panels burst or ablation due to the local over-heat in some extreme situation. In this work, an electrical heated evaporating experimental loop, including five parallel vertical tubes, is set up to evaluate the hydrodynamic characteristics of evaporation panels in a solar cavity receiver under various non-uniform heat fluxes. The influence of the heat flux concentration ratio, total flow rate, and system pressure on the flow distribution of parallel tubes is discussed. The hydrodynamic characteristics of working fluid in the heated surface of cavity receiver are obtained by performing experiments. This work offers information for development of large-capacity, high-efficiency, and large-scale cavity receivers.
[1] 杨敏林,杨晓西,左远志. 塔式太阳能热发电吸热器技术研究进展[J]. 科学技术与工程,2008,8(10):2632-2640.
[2] Baharoon D A,Rahman H A,Omar W Z W,et al. Historical development of concentrating solar power technologies to generate clean electricity efficiently:a review[J]. Renewable and Sustainable Energy Reviews,2015,41:996-1027.
[3] 魏进家,万振杰,屠楠. 塔式太阳能热发电水工质腔式吸热器研究进展[J]. 科学通报,2015,60(7):603-612.
[4] Mills D. Advances in solar thermal electricity technology[J]. Solar energy, 2004,76(1):19-31.
[5] 高维,徐蕙,徐二树,等. 八达岭太阳能塔式热发电吸热器水动力特性仿真研究[J]. 工程热物理学报,2012,8(33):1300-1304.
[6] Dong X W,Wang Y S,Wei J J, et al. Numerical simulation of the heat flux distribution in a solar cavity receiver[J]. Frontiers of Energy and Power Engineering in China,2010,4(4):571-576.
[7] Tu N,Wei J J,Fang J B. Selection of Surface Reflectivity for a Solar Cavity Receiver[C]//ASME 20144th Joint US-European Fluids Engineering Division Summer Meeting collocated with the ASME 201412th International Conference on Nanochannels,Microchannels,and Minichannels,USA(Chicago),American Society of Mechanical Engineers,August 3-7 in 2014:FEDSM2014-21331.
[8] 陈开拓. 镜场高密度聚焦热流下太阳能腔式吸热器水动力特性研究[D]. 西安:西安交通大学,2012.
[9] 刘杰. 电站锅炉过(再)热器壁温特性研究[D]. 北京:北京交通大学,2008.
[10] 柴岩,李斌. 浅谈超超临界垂直管圈直流锅炉水冷壁爆管原因及预防措施[C]//超超临界机组技术交流2013年会论文集.天津,中国电力科技网,2013年11月:165-171.
