静电除尘器中的活性炭喷射脱汞数值研究

doi:10.7523/j.issn.2095-6134.2021.02.005

中国科学院大学学报 ›› 2021, Vol. 38 ›› Issue (2): 189-197.DOI: 10.7523/j.issn.2095-6134.2021.02.005

静电除尘器中的活性炭喷射脱汞数值研究

冯宇轩, 罗坤, 樊建人

浙江大学能源清洁利用国家重点实验室, 杭州 310027

收稿日期:2019-06-10 修回日期:2019-09-05 发布日期:2021-03-15
通讯作者: 罗坤
基金资助:
国家自然科学基金（51390493）资助

Numerical research on mechanisms of the mercury capture by activated carbon injection within an electrostatic precipitator

FENG Yuxuan, LUO Kun, FAN Jianren

State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China

Received:2019-06-10 Revised:2019-09-05 Published:2021-03-15

摘要/Abstract

摘要： 依托Ansys Fluent平台及其二次开发程序建立静电除尘器（ESP）内除尘及活性炭汞吸附的数值模型，多场模型耦合了流场、电场、颗粒吸附、颗粒荷电及颗粒运动等子模型，通过该模型对静电除尘器内喷射活性炭汞吸附及颗粒收集的机理和影响因素进行探讨。结果表明活性炭颗粒粒径和ESP内的离子风效应对于除汞除尘效率均有重要影响。活性炭颗粒粒径越小，除汞效率越高，当活性炭粒径为5 μm时，ESP脱汞效率可达89.6%。而离子风的作用对于ESP内两种汞吸附机制有着不同的影响。其中，在ESP内悬浮活性炭颗粒对于汞的吸附机制占主导地位，而近壁面汞吸附效率较低，最大除汞效率不超过10%。将汞吸附子模型的计算结果与实验结果进行对比验证，发现该模型能较好地预测活性炭的脱汞率。

关键词: 静电除尘, 活性炭, 脱汞, 吸附机理, 数值模型

Abstract: Based on the Ansys Fluent platform along with its secondary development programs, this research developed a comprehensive numerical model for mercury capture by activated carbon injection and particle migration within an electrostatic precipitator (ESP). The multi-field model coupled sub-models such as flow field, electric field, mercury adsorption, particle charging, and particle motion. The mechanisms and crucial operation parameters of mercury adsorption by suspended activated carbon particles in electrostatic precipitators are fully discussed. The results show that both activated carbon particle size and ion wind effects have great impacts on combined removal efficiency of the mercury and particles. Reducing the size of sorbent particles (activated carbon) can promote mercury removal efficiency while decreasing the particle collection efficiency,the mercury removal efficiency will be 89.6% while the particle size is 5 μm. Additionally, the ion wind has distinct effects on the two mercury adsorption mechanisms in an ESP where the adsorption mechanism of mercury by suspended activated carbon particles is dominant, while the mercury capture efficiency near the wall is at a low level which is below 9%. The comparison between the experimental data and numerical results demonstrates that this model is able to predict the mercury removal efficiency by powdered sorbent injection with acceptable accuracy.

Key words: electrostatic precipitation, activated carbon, mercury removal, adsorption mechanism, numerical model

中图分类号:

TK123

冯宇轩, 罗坤, 樊建人. 静电除尘器中的活性炭喷射脱汞数值研究[J]. 中国科学院大学学报, 2021, 38(2): 189-197.

FENG Yuxuan, LUO Kun, FAN Jianren. Numerical research on mechanisms of the mercury capture by activated carbon injection within an electrostatic precipitator[J]. Journal of University of Chinese Academy of Sciences, 2021, 38(2): 189-197.

参考文献

[1] Hsi H C,Tsai C Y, Kuo T H, et al. Development of low-concentration mercury adsorbents from biohydrogen-generation agricultural residues using sulfur impregnation[J]. Bioresource Technology, 2011, 102(16):7470-7477.
[2] 杨振宇, 羌宁, 季学李. 美国燃煤电厂锅炉烟气中汞的研究进展[J]. 能源环境保护, 2003, 17(5):3-7.
[3] Pavlish J H, Sondreal E A, Mann M D, et al. Status review of mercury control options for coal-fired power plants[J]. Fuel Processing Technology, 2003, 82(2/3):89-165.
[4] United Nations Environment Programme(UNEP). Minamata convention on mercury[R]. Geneva, Switzerland:UNEP, 2013.
[5] Niksa S, Fujiwara N. Estimating Hg emissions from coal-fired power stations in China[J]. Fuel, 2009, 88(1):214-217.
[6] Lee S H, Rhim Y J, Cho S P, et al. Carbon-based novel sorbent for removing gas-phase mercury[J]. Fuel, 2006, 85(2):219-226.
[7] 陶叶. 火电机组烟气脱汞工艺路线选择[J].电力建设,2011,32(4):74-78.
[8] While H J. Industrial electrostatic precipitation[M]. New York:Addison-Wesley,1963.
[9] 周强,段钰锋,洪亚光,等. 模拟烟气活性炭喷射脱汞实验研究[J].中国电机工程学报,2013,33(35):36-43.
[10] 任建莉,周劲松,骆仲泱,等. 活性炭吸附烟气中气态汞的试验研究[J].中国电机工程学报,2004,24(2):171-175.
[11] Clack H L. Particle size distribution effects on gas-particle mass transfer within electrostatic precipitators[J]. Environmental Science and Technology, 2006, 40:3929-3933.
[12] Lawless P A, Sparks L E. Modeling particulate charging in ESPs[J]. IEEE Transactions on Industry Applications, 1988,24:922-927.
[13] Li Y, Zheng C H, Luo K, et al. CFD simulation of high-temperature effect on EHD characteristics in a wire-plate electrostatic precipitator[J]. Chinese Journal of Chemical Engineering, 2015,23:633-640.
[14] Long Z W, Yao Q. Numerical simulation of the flow and the collection mechanism inside a scale hybrid particulate collector[J]. Powder Technology, 2012, 215/216:26-37.
[15] Luo K, Li Y, Zheng C H, et al. Numerical simulation of temperature effect on particles behavior via electrostatic precipitators[J]. Applied Thermal Engineering,2015, 88:127-139.
[16] 毕文剑,李艳,罗坤,等.温度对静电除尘器内颗粒受力影响的数值模拟[J].中国科学院大学学报,2017,34(2):172-178.
[17] 近藤精一,石川达雄,安部郁夫.吸附科学[M].北京:化学工业出版社,2005:104-107.
[18] Clack H L. Mass transfer within electrostatic precipitators:in-flight adsorption of mercury by charged suspended particulates[J]. Environmental Science and Technology, 2006, 40:3617-3622.

静电除尘器中的活性炭喷射脱汞数值研究

Numerical research on mechanisms of the mercury capture by activated carbon injection within an electrostatic precipitator

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

访问统计

联系我们

[1]	冯宇轩, 罗坤, 樊建人. 静电除尘器中纳米颗粒运动与荷电特性[J]. 中国科学院大学学报, 2021, 38(3): 297-305.
[2]	毕文剑, 李艳, 罗坤, 樊建人. 温度对静电除尘器内颗粒受力影响的数值模拟[J]. 中国科学院大学学报, 2017, 34(2): 172-178.
[3]	杨小芳, 王明玉, 王丽亚, 赵建辉. 永定河生态修复地下水位主控因素与数值模拟预测不确定性[J]. 中国科学院大学学报, 2015, 32(2): 192-199.
[4]	张熙贵, 解晶莹, 夏保佳, 钦佩, 王涛. 碳基双电层电容器功率特性的研究[J]. 中国科学院大学学报, 2003, 20(4): 414-418.