Experimental studies on heat transfer characteristics of aqueous NaCl solution in static flash evaporation were carried out, with the mass fraction of aqueous NaCl solution varying between 0 and 0.26, initial height of water film varying between 0.1 to 0.4 m, and superheat varying from 1.5 to 40℃. Results showed that at different stages of flash evaporation the effects of superheat on instantaneous heat transfer coefficient were different. At the early stage, instantaneous heat transfer coefficient decreased with the superheat. At the beginning of the late stage, instantaneous heat transfer coefficient increased with the superheat. At the end of flash evaporation instantaneous heat transfer coefficient was nearly irrelevant to superheat. Results showed that the maximum instantaneous heat transfer coefficient value decreased with the increases of the initial height and initial concentration of water film. A fitting formula for instantaneous heat transfer coefficient of NaCl solution was proposed, and it was in good agreement with experimental results in the experimental range. The boiling states were significantly affected by the transient heat transfer coefficient in static flash evaporation.
WANG Chaoyang
,
ZHANG Dan
,
YANG Qingzhong
,
WANG Yu
,
YAN Junjie
. Experimental study on heat transfer characteristics of aqueous NaCl solution in static flash evaporation[J]. Journal of University of Chinese Academy of Sciences, 2017
, 34(2)
: 166
-171
.
DOI: 10.7523/j.issn.2095-6134.2017.02.007
[1] Miyatake O, Murakami K, Kawata Y, et al. Fundamental experiments with flash evaporation[J]. Heat Transfer-Japanese Research, 1973, 2(4):89-100.
[2] Gopalakrishna S, Lior N. Analysis of bubble translation during transient flash evaporation[J]. International Journal of Heat and Mass Transfer, 1992, 35(7):1753-1761.
[3] Kim J, Lior N. Some critical transitions in pool flash evaporation[J]. International Journal of Heat and Mass Transfer, 1997, 40(10):2363-2372.
[4] Saury D, Harmand S, Siroux M. Flash evaporation from a water pool:influence of the liquid height and of the depressurization rate[J]. International Journal of Thermal Sciences, 2005, 44(10):953-965.
[5] Augusto C M, Ribeiro J B, Gaspar A R, et al. Low-pressure-vaporization of free water -Characterization of the boiling regimes[J]. International Journal of Thermal Sciences, 2014,77:19-26.
[6] Raj M M A, Murugavel K K, Rajaseenivasan T, et al. A review on flash evaporation desalination[J]. Desalination and Water Treatment, 2016, 57(29):13462-13471.
[7] Shao Y X, Li Y J, Yang L B, et al. New experimental system for high pressure and high temperature flashing evaporation experiments[J]. Applied Thermal Engineering. 2014,66(1/2):148-155.
[8] Zhang D, Chong D T, Yan J J, et al. Experimental study on static flash evaporation of aqueous NaCl solution at different flash speed:heat transfer characteristics[J]. International Journal of Heat and Mass Transfer, 2013, 65(7):584-591.
[9] Zhang D, Chong D T, Yan J J, et al. Study on steam-carrying effect in static flash evaporation[J]. International Journal of Heat and Mass Transfer. 2012, 55(17/18):4487-4497.
[10] 杨庆忠,刘光耀,张丹,等.NaCl溶液静态闪蒸的蒸发特性[J].化工学报,2013,64(11):4068-4073.
[11] 于龙文,张丹,赵凯,等.静态闪蒸过程中的单个汽泡成长实验研究[J].工程热物理学报,2015,36(6):1274-1277.
[12] Zhang D, Chong D T, Yan J J, et al. Experimental study on static flash evaporation of aqueous NaCl solution[J]. International Journal of Heat and Mass Transfer. 2012, 55(23/24):7199-7206.
[13] Moffat R J. Contributions to the Theory of Single-Sample Uncertainty Analysis[J]. Journal of Fluid Engineering-Transactions of the ASME,1982, 104(2):250-260.
