An experimental rig was constructed for study of non-boiling cooling heat transfer of gas-liquid flow in subsea pipeline in oil and gas industry. The hydrodynamic and heat transfer characteristics of slug flow with 4℃ coolant in the annular pipe were measured by using sensors such as thermocouples,thermopiles,parallel conducting probes, etc. The convective heat transfer coefficients and flow parameters were obtained and a clear temperature difference was measured between the top and the bottom of the pipe. The effects of interfacial distribution of liquid slug and elongated bubble on the heat transfer coefficient were analyzed. The experimental results showed that the convective heat transfer coefficient was slightly affected by superficial gas velocity. The convective heat transfer between the fluid and the lower wall was significantly stronger than that between the fluid and the upper wall.
WANG Xin
,
DONG Chuanshuai
,
ZHANG Xiaoling
,
YUE Xiaoqing
,
HE Limin
. Experimental study on heat transfer and interfacial distribution of air-water slug flow in cooling process[J]. Journal of University of Chinese Academy of Sciences, 2017
, 34(2)
: 232
-236
.
DOI: 10.7523/j.issn.2095-6134.2017.02.017
[1] Fried L. Pressure drop and heat transfer for two-phase, two-component flow[C]//Chem Eng Prog Symp Series,1954, 50(9):47-51.
[2] Knott R F, Anderson R N, Acrivos A, et al. An experimental study of heat transfer to nitrogen-oil mixtures[J]. Industrial & Engineering Chemistry, 1959, 51(11):1369-1372.
[3] Sieder E N, Tate G E. Heat transfer and pressure drop of liquids in tubes[J]. Industrial & Engineering Chemistry, 1936, 28(12):1429-1435.
[4] Oliver D R, Wright S J. Pressure drop and heat transfer in gas-liquid slug flow in horizontal tubes[J]. British Chemical Engineering, 1964, 9(9):590-596.
[5] Dorresteijn W R. Experimental study of heat transfer in upward and downward two-phase flow of air and oil through 70 mm tubes[C]//Proc 4th Int Heat Transfer Conf, 1970, 5(5-9):1-10.
[6] Ueda T, Hanaoka M. On upward flow of gas-liquid mixtures in vertical tubes:3rd Report, heat transfer results and analysis[J]. Bulletin of JSME, 1967, 10(42):1008-1015.
[7] Shoham O, Dukler A E, Taitel Y. Heat transfer during intermittent/slug flow in horizontal tubes[J]. Industrial & Engineering Chemistry Fundamentals, 1982, 21(3):312-319.
[8] Hetsroni G, Yi J H, Hu B G, et al. Heat transfer in intermittent air-water flows.Part Ⅱ:Upward inclined tube[J]. International journal of multiphase flow, 1998, 24(2):189-212.
[9] Franca F A, Bannwart A C, Camargo R M T, et al. Mechanistic modeling of the convective heat transfer coefficient in gas-liquid intermittent flows[J]. Heat Transfer Engineering, 2008, 29(12):984-998.
[10] 王鑫, 徐静静, 祁雷, 等. 水平管空气-水段塞流冷却传热研究[J]. 工程热物理学报, 2014, 35(8):1563-1568.
